By American Water Heater. All other manufacturers use DI PAK MV) TCA-2 Left Handed Thermocouple Adapter (DI PAK MVFG) 1) 6 ft. length of 12-2 wire 1) 12 inch jumper wire 1) Flexible conduit connector 2) GSK-3 Spillage Switch DO NOT DESTROY
Universal Adapter Kit Converts screw-in element to replace round head, flat flange and universal flange. 12/Ctn. 0430604 Water Heater Thermocouple Fully universal. Fits push-in, screw-in or clamp-on type pilot burners. 24/Ctn. 0232501 18" 0232502 24"
Thermocouple Junction Adapter casing locating the end near the Thermocouple or ECO of water heater. Secure it with the cable clamps and self drilling screws provided, (See Diagram B1). DIAGRAM B DO NOT ALTER GAS SUPPLY INTO PRESSURE TAP PORT.
A thermocouple adapter (Robertshaw part number 10-038). -or- With the pilot flame lit, turn OFF the gas supply and start to count seconds (one-one thousand, two-one thousand). the water heater may not have enough air (in volume) to operate.
Wire WHKE Linear Limit in series with thermocouple junction adapter or high limit ECO of each water heater. 3. Make sure RED voltage jumper on UC1 is in the DRY position. 4. Connect 115 VAC supply voltage to L & N terminals on UC1.
Thermocouple Adapter Robertshaw 1950 Series Thermopiles 1980 SERIES SNAP-FIT Robertshaw Thermocouples 1970 SERIES UNI-COUPLES Honeywell boilers and water heater applications. Length Mfr# Item# 18” Q340A1066 G363-20 24” Q340A1074 G363-21 30” Q340A1082 G363-22
thermocouple needs to be changed, the complete manifold door assembly should be replaced with the newer version that has the externally mounted under side of the water heater is a specially designed “Flame Arrestor” plate. This
JUNCTION ADAPTER THERMOCOUPLE 950-0470 (JA1) LINEAR LIMIT SPILL SWITCH GAS VALVE 30 MILLIVOLT WATER HEATERS REQUIRE USE OF THE Wire WHKE Linear Limit in series with thermocouple junction adapter or high limit ECO of water heater. 3.
21 Thermocouple-All Propane Gas 6910566 6900725 22 Piezoelectric Igniter 6910430 6910430 “FG” Preﬁ x “BFG” Preﬁ x Item Copyright© by American Water Heater Company 2006. All rights reserved. Title: FlameGuardOutside.indd
A repair parts illustration and parts list for each water heater can be Element Adapter Kit Bagged 6900809 9000030015 $ 13.60 Adapts bolt-in style water heaters 18 Thermocouple & Igniter Wire 6910426 1 9006140015 12.00
This improvement eliminates the adapter fitting into the control allowing the use of only a single 45 degree elbow (3/8˝ flare x 1/4˝ N.P.T.). water heater. Pilot Flame Thermocouple On/Off Pilot Knob Air Shutter Temperature Lever Flame Spreader Burner Tube Gas Valve
• Universal Adapter Kit – (1) flat gasket, (1) round gasket, (1 complete “tune-up” for the water heater The value line for all your replacement parts needs. To place your order call 1-800-621-5622; fax 1-800-535-9538 33 Thermocouple Kit Thermostat Bracket Electric Thermostats
RESIDENTIAL WATER HEATER PARTS LIST MODELS: 6 40 XODS/CODS, 6 50 XODS/CODS PRINTED IN U.S.A. 0106 PART NO. 185508-000 Reliance Water Heater Parts Fulfillment
Residential water heater parts list models: pr6 40 xods/cods, prx 40 xods/cods, pr6 40 xbds/cbds, pr6 50 xods/cods, prx 50 xods/cods, pr6 50 xbds/cbds,
Disconnect thermocouple (C) from the water heater's gas valve (D). CAUTION: Do not use teflon tape or other sealant on any of these connections. 2. into adapter hole. Tighten thermocouple nut (C) securely. Remove and discard the fuse cover (G) from
1- TCA-1 Thermocouple Adapter (CK-20F) 1- TCA-2 Left Handed Thermocouple Adapter (CK-20FG) 1- 6 ft. length of 12-2 wire Allow the water heater to heat up to operating temperature, then disconnect the power to the gas pressure switch. 2.
The proper operation of the water heater that the thermocouple be bent smoothly without kinks or creases. 12. Insert the tip of the thermocouple through the hole in the front of the manifold door and route it in the same configuration as
Flammable Vapor Ignition Resistant Water Heater Troubleshooting Guide and Instruction for Service Connect a thermocouple adapter (BWC P/N 239-44642-00, Robertshaw P/N 75036) at the thermocouple location in the combination thermostat/gas valve.